AFBC boilers firing coal are not competitive with oil or gas .. versa. The disadvantage of an EHE is that it complicates the design and operation of the unit . There are more than 42 nos AFBC boilers operating worldwide which were designed as per Doosan Power System design and supplied either directly from the. It would be pointless to put whole Atmospheric Fluidised Bed Combustion (AFBC ) Boiler knowledge here. But from a quick search within Quora and Google you.

Author: Nijora Zulkicage
Country: Oman
Language: English (Spanish)
Genre: Health and Food
Published (Last): 18 April 2006
Pages: 156
PDF File Size: 6.39 Mb
ePub File Size: 13.40 Mb
ISBN: 497-6-39203-505-3
Downloads: 84484
Price: Free* [*Free Regsitration Required]
Uploader: Tygojar

Fabric filters have been used more widely for commercial applications instead of ESPs due to the low resistivity of ash produced by AFBC operatin. For abrasive fuels, special design considerations and provision of sacrificial shields.

Only two units have staged beds.

Atmospheric Fluidised Bed Combustion Boiler (AFBC)

The boileer characteristic that may be applicable to FBC waste appears to be toxicity; however, laboratory studies have indicated that typical FBC wastes would not be classified as hazardous according to toxicity characteristics. However, underbed feed designs tend to be more complex and expensive and less reliable. The effect of the entrained bed recycle rate on S02 removal for a Battelle test unit is presented in Figure 4.

operatio For small boilers meeting 1. This system was chosen over other FGD systems e. However, at this time, the impact of freeboard height on S02 removal is not defined well enough to make a quantitative adjustment. Given the small cost differences among S02 control options, it is unlikely that economics alone will be the deciding factor when a choice is made.


FBC capital costs are most attractive at the larger boiler sizes. Control Equipment Malfunction Provisions. Volume III, pp April Hydration enhanced sulfation HES involves spraying the spent bed material with water which passes through the sulfate layer coating the spent sorbent.

Research in these areas has resulted in improved system designs and has defined the direction of FBC technology development. Type H, 90, 2. PM’ Controld Control6 Control – – 58 1, 60 160 – 60 – 90 2, 92 192 – 3.


SCAh Boiler 5, 5, 5. A Among these are gas phase residence time and bed temperature which have previously been reviewed. Although the absolute costs for model boilers and various S02 control alternatives will vary from region to region, the cost differentials between alternatives are not expected to differ significantly on a regional basis.

Refer to Section 4. The water reaches the unreacted core of CaO which then hydrates to Ca OH 2, cracking the sulfate layer.

Although this report will build on the ITAR, it is intended to serve as a stand-alone document. One Alewife Place Cambridge. Hunan, China Sunagawa, Japan Vastervik. Continuous readings taken every 15 minutes.


Advantages of AFBC (Atmospheric Fluidized Bed Combustion) Boiler – ASKPOWERPLANT

Also, decreases below a A stoichiometric ratio of 0. Staging of”combustion air can also be used with the circulating bed design, but the tradeoff between S02 and NOX performance still exists. In conjunction with Energy Resources Co. Contingencies are included in capital costs to compensate for unpredicted events and other unforeseen expenses.

Coeur d’Alene, 10 Energy Resources Co.

boilre Limestone is fed to the upper bed where desulfurization and final combustion occur. Also, ongoing and near-term research involving the environmental characterization of advanced FBC designs is expected to result in more optimized performance.

Conversely, staged air and staged bed configurations, by the nature of their design and operation, include reducing zones in their combustion regions. Box 95 S 22 Partille. These cost differences are also dependent on the technical and economic assumptions that form their basis and thus should be used with opdration in view of this and the overall accuracy level. Foreign private and government research facilities are listed in Table 3.